|
06-20-2023, 07:47 PM
|
#1
|
Seasoned Camper
Join Date: Jul 2005
Location: ringgold
Posts: 53
M.O.C. #4165
|
Replace interior step cover
The plastic coating on interior steps is coming off. What have you done to repair and what type of material did you use. I am thinking vinyl flooring any other ideas
|
|
|
06-20-2023, 09:09 PM
|
#2
|
Montana Master
Join Date: Oct 2012
Location: Box Elder
Posts: 4,702
M.O.C. #12947
|
Sure is hard to speculate about a question when there is no indication of what rig this is in, model, year will help.
__________________
Bob & Becky
2012 3402RL
2012 Chevy 2500HD D/A CC 4WD
|
|
|
06-21-2023, 03:53 AM
|
#3
|
Montana Master
Join Date: Jan 2018
Location: Austin
Posts: 2,423
M.O.C. #21044
|
I found a previous post where he stated he had a 2016 3611FL.
The pic of the steps below is from the 2016 sales brochure.
A photo of your stair tread problem would help a lot!
__________________
MikenDebbie Aggie ‘77 in the sticks near Austin TX
2019 Chevy 3500 High Country DRW
2018 Montana 3921FB
Aussie Gus + Texas Heeler Jimmy
|
|
|
06-21-2023, 09:17 AM
|
#4
|
Seasoned Camper
Join Date: Jul 2005
Location: ringgold
Posts: 53
M.O.C. #4165
|
Interior steps
I have a 2016 3611RL . The plastic covering on steps are peeling off. The steps are rounded on the front. I was pondering if anyone else had this problem and what they did to fix it
|
|
|
06-21-2023, 09:36 AM
|
#5
|
Seasoned Camper
Join Date: Jul 2005
Location: ringgold
Posts: 53
M.O.C. #4165
|
Pictures of steps
Pictures of steps. I put duct tape on them so I wouldn’t be tripping on them
|
|
|
06-21-2023, 10:47 AM
|
#6
|
Seasoned Camper
Join Date: Dec 2022
Location: Hershey
Posts: 69
M.O.C. #32150
|
I covered mine using a light weight indoor/outdoor carpet using double sided contact tape. Ive done this in all of my 5’er. Currently I have two sets of interior steps as shown in the pictures. I also have two 75lb Labrador retrievers going up and down them. Carpet and tape lasts three years and than I replace it.
|
|
|
06-21-2023, 11:58 AM
|
#7
|
Montana Master
Join Date: Oct 2012
Location: Box Elder
Posts: 4,702
M.O.C. #12947
|
__________________
Bob & Becky
2012 3402RL
2012 Chevy 2500HD D/A CC 4WD
|
|
|
06-21-2023, 12:24 PM
|
#8
|
Montana Master
Join Date: Jan 2018
Location: Austin
Posts: 2,423
M.O.C. #21044
|
Edit: It looks like Bob Rohrman found the replacement treads at Trekwood. Wow - good work! But $132 per tread + shipping! Trekwood's shipping will be very expensive (based on what I have read here). If you assume shipping to be $100 - $150...your total will be close to $400.
I had never looked closely at my steps...I assumed they were wood treads. They look just like yours. They appear to be wood or plywood or composite wood (no idea which) with a plastic lam tread covering. If the laminate was coming off the steps in my unit - I would replace them with a standard hardwood tread of some sort (see screen shot below - $44 for 2 treads - 10.5" w x 28" long x 1" thick + shipping???), and forgo the OEM radius of the existing treads. I would stain the treads a dark color, screw them down with finish screws (because I do not have a pin nailor), and put some non-slip carpet treads over the wood. We found some sticky back door-mat carpet-like material at Walmart when our unit was new and that stuff is still safer to walk on than the bare treads.
It is a slow day of work for me today (I work at home)...the architects keep delaying the issuance of the next updated set of plans on my project...so I have nothing to do but wait. I have been searching and googling for all types of replacement RV interior stair (wood) treads. I have come up empty handed. Maybe I have used the wrong search terms - but all the usual suspects (Trekwood, Camping World, PPL Motorhomes) do not have anything for these stairs. I was going to suggest that you step into the abyss and call a Keystone dealer and see if they would order the parts for you. Be sure and have emergency rations and flashlight batteries on hand while you wait an eternity for them to get back to you.
To remove the treads - I would remove the two wood slotted vent covers on the risers (4 square bit screws for each vent), then I would gently start tapping the underside with a hammer to see if they moved or loosened. I would use my pry-bar for help if needed. I do not know if the treads are glued or nailed in place. Once they were off - I would screw down the new wood treads (finished and dried before I install them).
__________________
MikenDebbie Aggie ‘77 in the sticks near Austin TX
2019 Chevy 3500 High Country DRW
2018 Montana 3921FB
Aussie Gus + Texas Heeler Jimmy
|
|
|
06-21-2023, 01:10 PM
|
#9
|
Montana Master
Join Date: Oct 2018
Location: Anderson
Posts: 2,596
M.O.C. #22835
|
Cut a rubber mat to fit on top of each step, trim it to fit perfect, then tack or glue it down. All done then!
__________________
Who you are right now is a sum total off all you use to be.
2019 Montana High Country 375FL
2014 Chevy Silverado Duramax, 6.6L Dually
|
|
|
06-25-2023, 06:34 PM
|
#10
|
Established Member
Join Date: Jun 2017
Location: Greenville
Posts: 35
M.O.C. #19958
|
I realize this is not the same, but I put these in my Monty. They work great.
|
|
|
06-25-2023, 07:49 PM
|
#11
|
Montana Master
Join Date: Apr 2006
Location: Mesa az
Posts: 2,953
M.O.C. #5651
|
I would like something soft on my bare feet!!! The carpeted things listed above would seem ok. My unit si carpeted, and I like it. Just personal preference!!
__________________
Tom and Gail
2013 Mountaineer 362
2012 Silverado 2500
|
|
|
07-02-2023, 10:04 AM
|
#12
|
Montana Master
Join Date: Jan 2018
Location: Austin
Posts: 2,423
M.O.C. #21044
|
Sometimes I have posted a solution to a problem that I know nothing about...like my post #8 above. I had no idea how the steps were constructed in my RV. My stair tread suggestion will not work. Well - let me make some corrections.
We are out on a short trip this weekend and I felt hot air everytime I went from the bedroom to the living room and vice versa. I have read threads here on the forum about how lots of folks cover the wood louvers on the step risers to prevent hot air from getting into the coach from the basement. I had never really looked at this. Fortunately I found a screw bit that would work for the louver screws - removed the top louver completely but my bottom louver has the connection to the built-in vacuum, so I just moved it out enough to get a piece of cardboard behind the louvers. I put a piece of cardboard behind the top louver...cuts way down on the hot air coming thru. I'm sure there are better ways to do this. I have even seen someone here post about a custom made wood louver with a moveable/slide closure built in.
However - my intention is not to hijack the thread with ways to stop the basement heat migration. My intention is to provide the rough sketch below so folks can see how the steps are built. Knowing how they are put together changes recommendations for a fix to the OPs problem. Notice how the first tread is full width and the top tread is framed over it. Frankly - I am stumped. If the plastic laminate is flaking off (it is my assumption that the step's surface material is plastic lam - I really don't know what it is for sure) - I only see two options...simply cover up the tread with a sticky-stuck carpet/tread cover...or start over and completely rebuild the steps using tread material from Trekwood...or some other wood material of your choice.
See cross-section sketch below...and as architects always state - do NOT scale this drawing!
__________________
MikenDebbie Aggie ‘77 in the sticks near Austin TX
2019 Chevy 3500 High Country DRW
2018 Montana 3921FB
Aussie Gus + Texas Heeler Jimmy
|
|
|
02-18-2024, 07:23 AM
|
#13
|
New Member
Join Date: Feb 2024
Location: Grass Lake
Posts: 1
M.O.C. #33980
|
We are experiencing the same issue. Did you find a repair that works?
Super glue did not work well.
Thanks for the ideas.
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|